APRILIA TUONO 1000 — 2006 MANUAL Pdf Download.

6 Фев 2015 | Author: | Комментарии к записи APRILIA TUONO 1000 — 2006 MANUAL Pdf Download. отключены
Aprilia Tuono 1000

Page 1

Page 2

#xA9; aprilia s.p.a. — (VE) FOREWORD INTRODUCTION This manual is an important and manual is divided into chapters integral part of vehicle. Keep it with and by subject. The procedures your at all times, even if your are laid out by single operation, and operation is indicated by a #x2666;.


SAFETY WARNINGS GENERAL RULES WARNING Gasoline is flammable and The symbols and warnings throughout CARBON MONOXIDE manual have the following becomes explosive under When an operation must be with conditions. the engine position the motorcycle Safety When you find this in a well-ventilated area.

Page 4

FLUID KEEP CLUTCH AWAY FROM BATTERY GAS AND CHILDREN. ELECTROLYTE WARNING WARNING Brake fluid is poisonous. Never Under conditions, the ethylene glycol The gives off toxic and explosive brake fluid.

Should fluid contained in the engine is flammable: gases;.

Page 5

EMISSION WARRANTY acts or thereof: National Highway Safety aprilia s.p.a. that, at the time of Administration in addition to a) The removal or rendering by sale, this exhaust meets all applicable notifying

Page 6

CAUTION (V.I.N.) NUMBER) VEHICLE IDENTIFICATION product should be checked for Every vehicle produced by receives repair or replacement if the a vehicle identification number Description of the vehicle identification has increased significantly stamped: (V.I.N.), stamped on the steering.


MANUFACTURED BY APRILIA GVWR: 401 KG LB) GAWR: F. 152 KG (335 LB) WITH ZR 17 (56W) OR 120/70 ZR 17 (58 W) TIRE 17 x — DOT-D RIM, AT 250 KPA (36 COLD GAWR: R. 249 KG (548 LB) 180/55 ZR 17 (73 W) OR 190/50 ZR 17 (73 W) OR 190/55 ZR 17 (75 W) 17 x 6.00 — DOT-D AT 280 KPA (41 PSI) COLD.

Page 8: Of Contents


Page 9

CARBON CANISTER Never install accessories or parts not approved by Aprilia as equipment. This can degrade the and safety of your motorcycle, and can an upset with subsequent and serious injury or even

Page 10

If NHTSA receives complaints, it may open an investigation, and if it that a Do not use any tire other those reccomended and approved by Maintain safety defect in a group of vehicles, it may order a and remedy campaign.

Page 11

EVAPORATIVE EMISSION SYSTEM FOR OF CALIFORNIA ONLY. The system of: 1) Coal filter 2) Choke 3) Valve 4) Canister support 5) M6x20* flanged TE screw 6) tube 7) 5.5×10 fuel 8) D11.3 tie wrap 9) D10.1* tie 10)D8* tie wrap 11)D9.1* tie

Page 12

3 0. 0 0 0 k i l o m e t e r s ( 1 8. 6 4 1 m i l e s ). aprilia will your motorcycle at no cost contact aprilia USA, 10933 whichever occurs

Page 13

C a l i f o r n i a motorcycle dealer within the Administrative Code, may be aprilia s.p.a. Via G. Galilei, 1, United States of America in by other than an authorized Noale (VE) Italy #x201C;aprilia#x201D;)

Page 14

II. LIMITATIONS. This Control III. LIMITED B. NO EXPRESS EMISSION CONTROL warranty shall not cover any of A. The of aprilia under this WARRANTY IS GIVEN BY the following: Control System Warranty is EXCEPT AS SPECIFICALLY SET FORTH

Page 15

However, aprilia is not for these parts. The o w n e r i s r e s p o n s i b l e f o r t h e.

Page 16

COUNTRY CODE = country of (I, Holland South Africa UK, A, Switzerland New Zealand and must be to the Local aprilia Dealer as information for the Denmark Canada of spare parts or specific accessorie s of th e mo del you ha ve purchased.

Page 17


Page 18



Page 20

BASIC SAFETY The instructions given below normal operation of your and must be carefully observed. By these rules you will your own safety and the safety of around you. You will maximize the life and utility of vehicle.

Page 21

Observe all of the road. Particularly Avoid that could damage the ride with both on the pay attention to all warning, regulatory and or make you lose control. and feet on the footrests. informational Do not tailgate, do not attempt to increase shift gear without the clutch, if Avoid showing off popping wheelies).

Page 22

Use the vehicle#x2019;s specific fuels and by providing for positive closing of indicated in the #x201C;LUBRICANT Your dealer is ready and able to the CHART#x201D;; check the oil, and coolant help you with any problems that you levels

Page 23

This vehicle was not to be angle or color of your plate. Do not original parts, and use original aprilia equipped a sidecar or to be used to cover it, with a clear plastic

Page 24

Never race vehicles with your ride at the appropriate speed and open and close the throttle, to avoid unnecessary harsh avoid spinning or skidding the wheel. This is not only but also reduces fuel with both the front and brakes.

Page 25

Always posted and statutory Inevitably, the will look right at CLOTHING speed limits, but do not that you and yet swear that did not see you Before riding your make sure that can as fast as the speed limit all before they turned into your path.


Remember that loads to loosen with doubt regard to any accessory you riding, so check the security of would to install or any load you would load. like to carry, your Local aprilia use and maintenance TUONO 1000.

Page 27

Do not hang anything your vehicle This it more likely that the Never carry loosely items, make handlebars, or forks, because this wh e el w il l c o m e u p o f f t h e g r o un d. that everything that you on your will upset the of your vehicle, and especially on

Page 28

ARRANGEMENT OF THE MAIN 1) Fairing lug 7) Engine oil reservoir 13) Passenger left footrest 19) oil filter 2) Side fairings 8) side body panel closed/open) 20) Engine oil tank 3) steering damper 9) Rider 14) Drive chain 21) Engine oil 4) Left headlight.

Page 29

1) shock absorber 7) Auxiliary carrier (15A) 14) Front fluid reservoir 21) Rear control lever 2) Passenger footrest 8) Right side panel 15) Right headlight 22) right footrest (snapping, 9) Fuel tank 16) Right fairings 3) Tail light 10) expansion tank cap.


ARRANGEMENT OF THE INSTRUMENTS/CONTROLS 1) Clutch 7) Dimmer switch ( 2) Ignition lock ( 8) Turn indicator ( 3) Instruments and indicators 9) Horn ( 4) Front brake lever 10) 1 / TRIP 2 / MODE switch 5) grip 11) Engine kill ( 6) High-beam flasher — button (.

Page 31

INSTRUMENTS AND 1) Revolution counter 6) Blue warning light ( 2) Green light ( 7) Amber low fuel light ( 3) Amber stand light ( 8) Green turn warning light ( 4) Red general light ( 9) Red line light 5) digital display (coolant — clock — voltage — lap timer engine oil pressure.

Page 32

the ignition key is turned to with the stopped, all warning lights on for an LED checkup and go off after two seconds. If one or warning lights do not come on at stage, contact an aprilia Description Function Indicates the of revolutions of the engine per minute.


Now turn the key to #x201C; #x201D; and the coolant level, see page 60 ( M U L T I F U N C — aprilia dealer an TION COMPUT- If the maximum temperature is exceeded.

Page 34

MULTIFUNCTION COMPUTER When you the ignition key to , the During the initial all instruments following instrument lights will turn briefly show the current of the Controls on for 2 seconds: corresponding 1) Switch with three TRIP1 / #x2013;.

Page 35

TRIP METER #x2DA;F VOLTAGE TIME TRIP CURRENT SPEED #x2DA;F SPEED #x2DA;F TRIP AVERAGE SPEED #x2DA;F 1 AND 2 Briefly press SET (2) to toggle Mode these parameters. it for several In TRIP 1 and 2 the data trip 1 The MODE configuration the seconds to reset all data the selected and 2 is shown.

Page 36

TIME SETTINGS MENU confirming the SETTINGS selection mode allows you to set the clock. In (by SET (2) for several seconds) this hours increase by one unit the options are displayed: every SET (2) is pressed; when the EXIT is 12, it goes back to 1 if SET (2) is #x2013;.


When the battery is connected for the time, the instrument panel to running- in rpm value; the next the battery is connected it sets to the set value. RUNNING-IN RPM: MINIMUM RPM: 5000 RPM: 12000 When the set is exceeded, the alarm light (4) on the panel flashes until the goes below the.

Page 38

CHANGE THE CODE THE NEW CODE This function is when the old code is Once the is completed, the available and is to be changed. goes back to the DIAGNOSIS If you entered with the code, Within this function, the message operation will not be

Page 39

To enable it, you require a set for time recording. Briefly password available only to the SET (2) to start recording with the Authorized Service Centers. lap Language Press SET (2) again the first 10.

Page 40

A l a r m s a r e d i v i d e d i n t w o g r o u p s as aprilia Dealers and depending on their

Page 41

CONTROLS CONTROLS ON THE HAND GRIP 1) HORN ( The horn sounds when the is pressed. 2) TURN INDICATOR ( To activate the left turn move the switch to the left. To the right turn indicator, the switch to the right.

Page 42

your Local aprilia of a stuck throttle or other Dealer for repairs. Failure to runaway.

Page 43

Position Key removal The steering It is possible is to remove the It is neither key. to start the (LOCK) immobilizer nor to system is Steering lock on the activated after lights. the key is

Page 44

UNLOCKING/LOCKING THE T h e t a i l s e c t i o n o f t h e v e h i c l e To lock the seat/seat cover PASSENGER COVER accommodates a convenient / tool kit (2): c o m p a r t m e n t. s i m p l y r e m o v e t h e Position the on the stand, see.

Page 45

KIT COMPARTMENT LUGGAGE RACK Small parcels can be carried on the r e a c h t h e g l o v e / t o o l k i t passenger seat, using bands. The compartment, proceed as elastic bands are hooked to the two the passenger seat/seat cover.


SPECIAL TOOLS To perform specific operations, it is advisable to use the special tools (to be requested to an dealer): Tool Operations (1) for the rear support stand, see of the vehicle on the rear stand.


MAIN COMPONENTS WARNING G a s o l i n e p o i s o n o u s a n d carcinogenic and contains chemical substances that cause defects and o t h e r r e p r o d u c t i v e p r o b l e m s. I f Gasoline is extremely and in some conditions can become

Page 48

Lift the little (1). When refueling are completed: WARNING Insert the key (2) in the cap (3). WARNING Turn the key (2) pull it and Make sure the fuel filler cap (4) is open the filler cap (4). properly

Page 49

In case of oil leakage do not your CAUTION your aprilia Dealer. Failure to Before using the vehicle, it observe this warning can to engine repaired by your aprilia Dealer.

Page 50

The brake system is equipped indicate any discrepancy, contact two discs, one on the right and one on the Local Dealer before riding. Wet seriously degrade the left of the front wheel. performance of brakes. When the.


Have the brake disks by an Official aprilia dealer the first 625 mi (1,000 km) and every mi (10,000 km) thereafter. Before ride, check the brake

Page 52

WARNING Avoid any exposure of the brake fluid to The brake fluid is hygroscopic and in contact with air it absorbs its Leave the brake fluid open O N L Y f o r t h e t i m e n e c e s s a r y f o r topping up.

Page 53

THE SYSTEM CAUTION is reduced in any have your vehicle by your Local aprilia It NOTE Carry out these only on a When the disc wear out, the level.


WARNING Do not add any additives or other to the brake fluid. Top up the reservoir brake fluid, until the reaches the #x201C;MAX#x201D; mark. the gasket (4) in its seat correctly.

Do not tilt the reservoir (1) even if the cap (2) is

Page 55

CHILDREN. brakes is in any way, have your and the bike with a clutch is vehicle serviced by your aprilia DISPOSE OF USED FLUID anything less perfect is very likely

Page 56

Aprilia Tuono 1000

Loosen and remove the cap WARNING Remove the gasket Have your Local Dealer check the clutch every 4,650 mi (7,500 THE SYSTEM km). NOTE.


Local aprilia Dealer. It may be to have your dealer In order to fill the reservoir to

Page 58

(4) is set at the desired distance. that the eccentric is firmly in the shift lever (10). If it is necessary to further adjust the lever, contact your aprilia dealer. use and maintenance 1000.

Page 59

If you wish to the clearance of the ADJUSTING THE REAR CAUTION rear brake (4): PEDAL If this is not observed, the brake Loosen the nut (5) on the master The rear brake (1) is adjusted to fit will remain applied, with cylinder rod (6) and run it as far most riders during

Page 60

Have the coolant by your Official violently. Dealer. aprilia dealer 2 years. If it comes in contact the skin or The coolant is made up of 50% and with your clothing, it may severe WARNING 50% antifreeze.


CAUTION Have any damage or repaired soap. Should you get in your eyes, by your aprilia Dealer. Do not If dirt has on or around the flush with of cool water and attempt to the cooling system filler wipe the cap and the area around seek medical attention.

Page 62

DATA), or that been specifically to slow you to a Non-compliance km), see page 137 DATA). approved by aprilia for vehicle. with these may cause Pressure measurement always be accidents which can in injuries or.

Page 63

AUTOMATIC ON WARNING WARNING Your is equipped with lights come New tires are often with a Periodically inspect the exhaust on automatically as soon as the switch slippery mold compound. Scrub system, the exhaust pipe and (2) is turned to

Page 64

INSTRUCTIONS FOR USE GETTING ON AND OFF THE VEHICLE T h e s t a n d h a s b e e n d e s i g n e d t o The instructions below be followed support the weight of the and a with the maximum care in to avoid injury to persons and to property.

Page 65

GETTING ON THE Push down on the side lever with your heel until the side is fully Grasp the handlebar and get down. on the vehicle without your NOTE weight the side stand. If you cannot both feet on NOTE the set your right foot on the.

Page 66

6,250 mi km) thereafter, the SERVICE warning (2) on the right display. In this have a Local aprilia perform all service operations as in the scheduled maintenance chart, see 81 (REGULAR SERVICE INTERVALS

Page 67

PRE-RIDE CHECKS Component Check Page the operation, the idle … of the levers, the fluid level and sure there are 50, 51, 52, no leaks. 53, 97 and rear disc brakes the wear of the pads. If necessary, top up the tank.

Page 68

WARNING Be not to drop the vehicle when you sit on it. Sit astride the vehicle, see page 64 ( G E T T I N G O N A N D O F F T H E

Page 69

Hold the vehicle in by applying at least one brake. in the clutch lever (7) completely and put the lever (8) in neutral so that the warning light #x201C; (9) is on. The vehicle is equipped with a start feature controlled by the ECU operates automatically when the engine from cold.


Contact your Local Dealer for repairs. Failure to this warning can lead to a accident and result in injury or ….

Page 71

CAUTION WARNING If you carry a passenger, him/her When the vehicle is new to practice Do not release the clutch too or the vehicle will rear in the air (do a not to around unduly, and to keep in the rearview mirrors.

Page 72

Failure to observe this the clutch lever (3) and lower the a n d c a u s e s r o u g h a n d j u d d e r i n g can lead to engine seizure, shift lever (4) to shift

Page 73

; i m m e d i a t e ly contact your aprilia dealer lose of your vehicle.

Page 74

RUNNING-IN WARNING The internal parts of the engine and Pay close attention to any obstacles the vehicle has been operated for must be properly run-in to or of the road surface. Uneven 600 mi km) perform the #x201C;checking ensure long life and dependable rails, manhole covers, operations#x201D;.

Page 75

STOPPING the vehicle has come to rest: It is very important to choose a Position the shift lever (3) in WARNING parking area, the road signs (green light #x201C; #x201D; (4) If possible, avoid stopping and the indications given below.


To leave the parking lights on: see page 131 (PARKING-LIGHT BULB). Do not the ignition on if you have WARNING (for emergency) the engine by the engine stop switch to the sure the vehicle is stable #x201C;.

Page 77

SUGGESTIONS TO THEFT CAUTION Do not use any brake devices. Failure to observe warning can seriously damage the system and lead to an accident and in serious injuries or …. leave the key in the ignition switch,

Page 78

IMMOBILIZER (if fitted) The is fitted with an immobilizer system that is automatically each time the ignition key is from the switch. Store the key in a safe place. Immobilizer keys cannot be duplicated.

If keys are lost, you will h a v e t o h a v e a n u m b e r o f v e h i c l e replaced (rather than the key-operated locks).

Page 79

Do not to contact your Local — GENERAL ADVICE]. hot to cause serious burns. Dealer who has all the latest Avoid the to hold any part of factory and tools to properly the vehicle in mouth. The coatings, service vehicle.

Page 80

(1) appears on the display. a n d m u s t b e m a i n t a i n e d a t t h e In this case a Local aprilia Dealer values.

Page 81

24 months T H E S E O P E R A T I O N S M A Y plug CARRIED OUT BY YOUR aprilia Dealer, OR BY THE OWNER OF THE Air VEHICLE. Engine oil filter.


(10,000 km) or 12 (20,000 km) or 24 SHOULD BE PERFORMED BY (1,000 km)] use months months YOUR aprilia Dealer. Rear absorber every 6,250 mi (10,000 km): = check and adjust, lubricate or Transmission and controls change, if necessary;.


MAINTENANCE RECORD Owner Owner Address Owner Number Vehicle Identification (V.I.N.) (frame number) see 86 (IDENTIFICATION DATA) Engine see page 86 (IDENTIFICATION DATA) Local Dealer Name Local Dealer Address Local Dealer Telephone

Aprilia Tuono 1000
Aprilia Tuono 1000
Aprilia Tuono 1000
Aprilia Tuono 1000

Interesting articles

Tagged as:

Other articles of the category "Aprilia":

Our partners
Follow us
Contact us
Our contacts


Born in the USSR


About this site

For all questions about advertising, please contact listed on the site.

Motorcycles catalog with specifications, pictures, ratings, reviews and discusssions about Motorcycles.