Triumph Daytona, Speed Triple, Sprint Repair Manual 1997-2005 | Motorcycles catalog with specifications, pictures, ratings, reviews and discusssions

Triumph Daytona, Speed Triple, Sprint Repair Manual 1997-2005

24 May 2015 | Author: | Comments Off on Triumph Daytona, Speed Triple, Sprint Repair Manual 1997-2005
Triumph Daytona T595

Triumph Daytona, Speed Triple, Sprint, Tiger Repair Manual 1997-2005

Item Description Table of Contents Specifications

The 1995-2005 Triumph Daytona, Speed Triple, Sprint, Tiger repair manual by Haynes covers the following motorcycle models:

Triumph T595/955i Daytona, 1997-2005

Triumph T509 Speed Triple, 1997-1998

Triumph 955i Speed Triple, 1999-2004

Triumph Sprint ST, 1999-2004

Triumph Sprint RS, 2000-2003

Triumph Tiger, (885cc) 1999-2000

Triumph Tiger, (955cc) 2001-2005

Note: the 1050cc Speed Triple and Sprint are not covered by this manual. See 2005-2009 Triumph 1050 Sprint ST, Speed Triple, Tiger for newer model coverage.

Book Excerpt: 1997-2005 Triumph Daytona, Speed Triple, Sprint Repair Manual

ENGINE, CLUTCH AND TRANSMISSION – 1997 TO 2001 MODELS STARTER CLUTCH CHECK

If you suspect the starter clutch of being faulty, a simple check can be performed with the engine in the frame.

Remove the starter motor (see Chapter 8).

Using your finger inserted in the starter motor aperture, check that the starter idle/reduction gear turns freely anti-clockwise (as you look at it), and locks solid when turned clockwise. If not, remove the starter clutch for further investigation.

REMOVAL

Remove the engine from the frame and separate the crankcase halves (see Sections 5 and 21). The alternator/starter clutch drive is housed in the upper crankcase half. Remove the transmission shafts (see Section 27).

If not already done, remove the rubber dampers from the alternator drive housing (see illustration).

Counter-hold the drive shaft bolt (which also secures the alternator driven gear) and unscrew the drive housing nut (see illustrations).

Remove the nut, washer and the housing (see illustrations). Withdraw the bolt and washer from the other side of the casing, and then slide the driven gear off the shaft (see illustrations).

BRAKES, WHEELS AND TIRES REAR BRAKE MASTER CYLINDER

If the master cylinder is leaking fluid, or if the pedal does not produce a firm feel when the brake is applied, and bleeding the brake does not help (see Section 10), and the hydraulic hose and brake caliper are in good condition, then master cylinder overhaul is recommended.

Before disassembling the master cylinder, read through the entire procedure and make sure that you obtain any replacement parts required.

Also you will need some new DOT 4 brake fluid, some clean rags and internal circlip pliers.

Note: To prevent damage to the paintwork from spilled brake fluid, always cover the surrounding components when working on the master cylinder.

CAUTION! Disassembly, overhaul and reassembly of the brake master cylinder must be done in a spotlessly clean work area to avoid contamination and possible failure of the brake hydraulic system components.

REMOVAL

On Daytona, Speed Triple and Sprint models, remove the seat cowling, and on Tiger models remove the right-hand side panel (see Chapter 7).

Place some rags around the master cylinder and prepare a small container to hold some brake fluid. Remove the reservoir cap, diaphragm plate and diaphragm (see illustrations).

TABLE of CONTENTS:

THE TRIUMPH DAYTONA, SPEED TRIPLE, SPRINT, TIGER

Introduction

Identification numbers

Buying spare parts

Daily (pre-ride) checks

Engine oil level check

Coolant levels

Brake fluid levels

Suspension, steering and final drive checks

Tire checks

MAINTENANCE

Routine maintenance and servicing

Specifications

Recommended lubricants and fluids

Maintenance schedule

Component locations

Triumph Daytona T595

Maintenance procedures

REPAIRS and OVERHAUL

Engine, transmission and associated systems

Engine, clutch and transmission: 1997 to 2001 models

Engine, clutch and transmission: 2002-on models

Cooling system

Engine management system (fuel and ignition)

Chassis and bodywork components

Frame and suspension

Final drive

Brakes

Wheels and tires

Fairing and bodywork

Electrical system | Wiring diagrams

REFERENCE

Tools and workshop tips

Storage

Troubleshooting

Subject: 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005 Triumph Daytona T595, 955, Speed Triple, T509, Sprint, Tiger service, maintenance, repair. ISBN-10: 1844252914 | ISBN-13: 9781844252916 | Haynes 3755


Publisher: Haynes Manuals

Pages: 288 – Hundreds of bw photos and illustrations

Binding: Hardcover – 8.5 x 11 inches

ISBN: 9.78E+12

Years: 1997 – 2005

Triumph Daytona T595
Triumph Daytona T595
Triumph Daytona T595
Triumph Daytona T595
Triumph Daytona T595
Triumph Daytona T595
Triumph Daytona T595

Interesting articles

Other articles of the category "Triumph":

Translation
Our partners
Follow us
Contact us
Our contacts

dima911@gmail.com

Born in the USSR

423360519

About this site

For all questions about advertising, please contact listed on the site.


Motorcycles catalog with specifications, pictures, ratings, reviews and discusssions about Motorcycles.